Product ID:38-032, AMPLEX 15
MSDS Date:03/14/1991
FSC:9150
NIIN:01-041-3207
MSDS Number: BPKPN

CITGO PETROLEUM CORP

TULSA, OK 74102
US

Emergency Phone: 318-491-6215;800-424-9300(CHEMTREC)

Info Phone: 918-495-5933

Cage: 7X110

CITGO PETROLEUM CORP

3758 TULSA, OK 74102 US

Telephone: 918-495-5933

Cage: 7X110

MINERAL OIL, PETROLEUM DISTILLATES, HYDROTREATED (MILD)

CAS: 64742-52-5

RTECS: PY8035000

Fraction By Weight: >80%

OSHA PEL 5MG/M3 (OIL MIST)

ACGIH TLV: 5MG/M3;10 STEL(MIST)

GAS OIL, BLEND; (MINERAL SEAL OIL)

CAS: 64741-44-2

RTECS: LX3296000

Fraction By Weight: <20%

OSHA PEL 5 MG/M3 (OIL MIST)

ACGIH TLV: 5MG/M3;10STEL (MIST)

TECHNIQUE, SEEK SKILLED ADVICE.

RTECS: 9999999ZZ

MANDATED STANDARDS AS EVALUATED BY DESIGNATED

RTECS: 9999999ZZ

LD50 LC50 Mixture:SEE INGREDIENT 1.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHAL:LOW RISK OF INHAL. IN
ENCLSD SPACES OR WHEN HOT, VAPS MAY REACH CONC SUFFICIENT TO CAUSE
DROW, DIZZ, HDCH, NAUS OR LUNG IRRIT. MISTS ABOVE TLV MAY CAUSE
CHEM PNEUMIT. SKIN:TRANSIENT, SLIG HT IRRIT. EYES:MAY BE MILDLY
IRRITATING. INGEST:GENERALLY LOW TOX. VERY LGE AMTS MAY CAUSE
GENERALIZED (EFTS OF OVEREXP)
Explanation of Carcinogenicity:CAS NO. 64742-52-5 IS LISTED BY THE
RTECS AS AN IARC GROUP 1 CARCINOGEN.
Effects of Overexposure:HLTH HAZ:DEPRESS, HDCH, DROW, NAUS, VOM OR
DIARR. SMALL DOSES MAY PRDCE IRRIT & DIARR. CHRONIC:PRLNGD &/OR
FREQUNT CONT MAY CAUSE DRYING, CRACKING (DERM) OR FOLLICULITIS.
RPTD, EXCESSIVE EXPOS TO MIST S/FUMES MAY INDUCE PULM IRRIT OR
CHRONIC BRONCH. SLIGHTLY TOX, 1PT TO 1QT IS APPROX LETHAL DOSE FOR
150LB HUMAN ADULT.
Medical Cond Aggravated by Exposure:NONE.

First Aid:INHAL:MOVE TO FRESH AIR. RESP SUPPORT, IF NEC. SEEK MD.
SKIN:WASH W/SOAP & WATER. DO NOT WEAR HEAVILY CONTAMD CLTHG BEFORE
LAUNDERING. EYES:FLUSH W/LGE VOLUMES OF WATER FOR AT LEAST 15 MINS.
SEEK MD I F ANY COMPLICATIONS ARISE. INGEST:DO NOT INDUCE VOM. SEEK
MED AID. INJECTION:SUBCUTANEOUS INJECTION IS A MED EMER. SEEK MD
IMMED. NOTE TO MD:FOLLOWING INGEST AT A VISCOSITY OF 85 SUS
(100F),(SUP DAT)

Flash Point:SUPP DATA
Extinguishing Media:CO*2, DRY CHEMICAL, FOAM & WATER FOG.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:WATER MAY CAUSE FROTHING.

Spill Release Procedures:REMOVE SOURCES OF HEAT OR IGNITION, PROVIDE
ADEQUATE VENTILATION & CONTAIN LEAK. SMALL:ABSORB W/SUITABLE MATL
SUCH AS RAGS, STRAW OR SAND. LGE:CONTAIN SPILL IN EARTHEN DIKES FOR
LATER RECOVERY. REPOR T SPILLS AS REQD TO APPROP AUTHORITIES.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:STORE BELOW 150F. DO NOT APPLY HIGH
HEAT OR FLAME TO CONTAINER. KEEP SEPARATE FROM STRONG OXIDIZING
AGENTS. AVOID PROLONGED CONTACT W/USED OIL.
Other Precautions:EMPTY CONTRS MAY CONTAIN PROD RESIDUE WHICH COULD
INCL FLAMM/EXPLOSIVE VAPORS. CONSULT APPROPRIATE FEDERAL, STATE &
LOCAL AUTH BEFORE REUSING, RECONDITIONING, RECLAIMING, RECYCLING OR
DISPOSING OF EMP TY CONTRS &/OR WASTE RESIDUES OF PROD.

Respiratory Protection:NORMALLY NONE REQUIRED. IF HIGH VAPOR OR MIST
CONCENTRATIONS EXPECTED, USE NIOSH/MSHA APPROVED RESPIRATOR FOR
ORGANIC VAPORS & MISTS.
Ventilation:USE IN WELL VENTD AREA. IN CONFINED SPACE, MECH VENT MAY BE
REQD TO KEEP LEVELS OF CERTAIN COMPONENTS BELOW (ING 4)
Protective Gloves:OIL IMPERVIOUS GLOVES.
Eye Protection:CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:WEAR BODY-COVERING WORK CLOTHES TO AVOID
PROLONGED OR REPEATED EXPOSURE. LAUNDER SOILED WORK CLOTHES BEFORE
REUSE.
Work Hygienic Practices:WASH EXPOSED SKIN THOROUGHLY W/SOAP & WATER.
Supplemental Safety and Health
FL PT:338F (COC); 311F (PMC). FIRST AID PROC:THERE EXISTS A DEFINITE
RISK OF ASPIR INTO LUNGS. FOR QTYS ABOVE FEW DROPS, CAREFUL CUFFED
TUBE LAVAGE IS RECOM. ASPIRATED MATL MAY CAUSE CHEM PNEUMIT OR L
IPOID PNEUMIA. SUBCUTANEOUS OR INTRAMUSCULAR INJECTION REQS PROMPT
SURGICAL DEBRIDEMENT, IF NOT FAMILIAR WITH (ING 3)

Boiling Pt:B.P. Text:249F,121C
Vapor Density:>1
Spec Gravity:0.91 (H*2O=1)
Evaporation Rate & Reference:<1 (BUTYL ACETATE=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR LIQUID; MILD ODOR.
Percent Volatiles by Volume:NEGLIG

Stability Indicator/Materials to Avoid:YES
STRONG OXIDANTS, STRONG ACIDS & CAUSTICS.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:CO*2 (CO UNDER INCOMPLETE COMBUSTION).

Waste Disposal Methods:IT IS RESPONSIBILITY OF USE TO DETERMINE IF
MATERIAL IS A HAZARDOUS WASTE AT TIME OF DISPOSAL. CHECK BEFORE
DISPOSING TO BE SURE YOU ARE IN COMPLIANCE W/ALL APPLICABLE LAWS &
REGS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.